Optimising Membrane Performance in High-Recovery Seawater Reverse Osmosis Systems to Reduce Biofouling Using Modelling and Simulation

Main Article Content

Nageswara Rao Lakkimsetty
Shabib Al Rashdi
Khalid Said Ambusaidi
Clement Varaprasad Karu

Abstract

The increasing demand for freshwater due to human activities underscores the need for alternative water sources. Desalination of seawater and water reclamation are reliable methods for producing potable water. Among desalination techniques, seawater reverse osmosis (SWRO) is widely adopted due to its lower energy consumption compared to thermal desalination, smaller footprint, reduced waste generation, and consistent performance. Efficient pre-treatment is vital to ensure high-quality feed water and protect RO membranes, which are prone to fouling, scaling, and chemical damage. The HYDRAcapMAX80 ultrafiltration module offers high permeate flux and effectively removes total suspended solids and organic contaminants. A two-pass, two-stage SWRO system was developed, achieving a recovery rate of 45%, salt rejection of 99.1%, and energy consumption of 3.26 kWh/m³. Post-treatment yields permeate water that meets WHO standards, with TDS at 407 ppm, calcium at 6.4 ppm, sodium at 145 ppm, chloride at 204 ppm, fluoride at 0.39 ppm, and a pH of 7.2. System performance was tested under varying salinity and temperature conditions. Higher salinity and lower feedwater temperatures increased TDS and energy consumption, but maintained acceptable performance. This system demonstrates energy-efficient desalination while delivering high-quality drinking water.

Article Details

How to Cite
Lakkimsetty, N. R., Rashdi, S. A. ., Ambusaidi, K. S. ., & Karu, C. V. (2026). Optimising Membrane Performance in High-Recovery Seawater Reverse Osmosis Systems to Reduce Biofouling Using Modelling and Simulation . Journal of Studies in Science and Engineering, 6(1), 156–173. https://doi.org/10.53898/josse2026617
Section
Research Articles

References

R. Namdeti et al., "Enhanced Lead and Zinc Removal via Prosopis Cineraria Leaves Powder: A Study on Isotherms and RSM Optimization," Journal of Environmental & Earth Sciences, vol. 7, no. 1, pp. 292-305, 2025, doi: https://doi.org/10.30564/jees.v7i1.7474.

H. A. Gheilani, K. Matsuoka, A. AlKindi, S. Amer, and C. Waring, "Fish kill incidents and harmful algal blooms in Omani waters," Journal of Agricultural and Marine Sciences, vol. 16, pp. 23-33, 2011, doi: https://doi.org/10.24200/jams.vol16iss0pp23-33.

A. Al-Azri et al., "The occurrence of algal blooms in Omani coastal waters," Aquatic Ecosystem Health & Management, vol. 15, pp. 56-63, 2012, doi: https://doi.org/10.1080/14634988.2012.672151.

Z. Wang, H. Wang, H. Huang, and Z. Qiu, "A Three-Stage Coordinated Optimization Scheduling Strategy for a CCHP Microgrid Energy Management System," Processes, vol. 8, no. 2, p. 245, 2020, doi: https://doi.org/10.3390/pr8020245.

V. Bonnelye, M. A. Sanz, J.-P. Durand, L. Plasse, F. Gueguen, and P. Mazounie, "Reverse osmosis on open intake seawater: pre-treatment strategy," Desalination, vol. 167, pp. 191-200, 2004, doi: https://doi.org/10.1016/j.desal.2004.06.128.

J. Haarhoff and J. K. Edzwald, "Adapting dissolved air flotation for the clarification of seawater," Desalination, vol. 311, pp. 90-94, 2013, doi: https://doi.org/10.1016/j.desal.2012.10.035.

J. Kavitha, M. Rajalakshmi, A. R. Phani, and M. Padaki, "Pretreatment processes for seawater reverse osmosis desalination systems—A review," Journal of Water Process Engineering, vol. 32, p. 100926, 2019, doi: https://doi.org/10.1016/j.jwpe.2019.100926.

R. Namdeti et al., "Innovative Approaches in Water Decontamination: A Critical Analysis of Biomaterials, Nanocomposites, and Stimuli-Responsive Polymers for Effective Solutions," Journal of Environmental & Earth Sciences, vol. 7, no. 1, pp. 92-102, 2025, doi: https://doi.org/10.30564/jees.v7i1.7476.

S.-H. Kim, C.-S. Min, and S. Lee, "Application of dissolved air flotation as pretreatment of seawater desalination," Desalination and Water Treatment, vol. 33, no. 1-3, pp. 261-266, 2011, doi: https://doi.org/10.5004/dwt.2011.2650.

M. Maniyar, "Algae bloom driving up desalination cost in Oman," Times of Oman, vol. 20, 2018.

W. L. Ang, A. W. Mohammad, N. Hilal, and C. P. Leo, "A review on the applicability of integrated/hybrid membrane processes in water treatment and desalination plants," Desalination, vol. 363, pp. 2-18, 2015, doi: https://doi.org/10.1016/j.desal.2014.03.008.

R. Miranda, I. Latour, and A. Blanco, "Understanding the Efficiency of Aluminum Coagulants Used in Dissolved Air Flotation (DAF)," Frontiers in Chemistry, vol. 8, p. 27, 2020, doi: https://doi.org/10.3389/fchem.2020.00027.

M. Saeed, M. Al-Nomazi, and A. Al-Amoudi, "Evaluating suitability of source water for a proposed SWRO plant location," Heliyon, vol. 5, no. 1, p. e01119, 2019, doi: https://doi.org/10.1016/j.heliyon.2019.e01119.

Y. Shutova, B. L. Karna, A. C. Hambly, B. Lau, R. K. Henderson, and P. Le-Clech, "Enhancing organic matter removal in desalination pretreatment systems by application of dissolved air flotation," Desalination, vol. 383, pp. 12-21, 2016, doi: https://doi.org/10.1016/j.desal.2015.12.018.

S. R. S. Alalyani, N. R. Lakkimsetty, and F. Shaik, "Modeling and optimization of bioethanol production yield from corn starch using response surface methodology," Environment, Development and Sustainability, 2023, doi: https://doi.org/10.1007/s10668-023-02990-y.

N. R. Lakkimsetty, S. Karunya, S. Feroz, L. Motilal, P. Saidireddy, and G. Suman, "Synthesis, characterization and application of polymer composite materials in wastewater treatment," Materials Today: Proceedings, vol. 59, no. 3, pp. 1726-1734, 2022, doi: https://doi.org/10.1016/j.matpr.2022.04.050.

N. S. Al-Reyami, F. Shaik, and N. R. Lakkimsetty, "Environmental impact on usage of treated effluents from ISTP for irrigation," Journal of Water Process Engineering, vol. 36, p. 101363, 2020, doi: https://doi.org/10.1016/j.jwpe.2020.101363.

N. R. Lakkimsetty and F. Shaik, "Review on an integrated pre-treatment system to reduce membrane accelerated biofouling during red tide occurrences in Oman," Materials Today: Proceedings, 2023, doi: https://doi.org/10.1016/j.matpr.2023.06.290.

F. Y. M. Salih, S. Karunya, N. R. Lakkimsetty, and F. Shaik, "Treatment of petroleum wastewater using synthesised haematite (α-Fe₂O₃) photocatalyst and optimisation with response surface methodology," International Journal of Environmental Analytical Chemistry, vol. 102, no. 18, 2022, doi: https://doi.org/10.1080/03067319.2020.1817422.

F. Shaik, S. S. Al-Siyabi, N. R. Lakkimsetty, M. A. Syed, and N. Mohammed, "Assessment of Falaj Water Quality," Asian Journal of Water, Environment and Pollution, vol. 18, no. 1, pp. 25-30, 2021, doi: https://doi.org/10.3233/AJW210004.

R. Stover and G. Crisp, "SWRO process design using advanced energy recovery technology," presented at the Proc. Enviro 2008 Conference, Melbourne, Australia, 2008.

S. A. A. Tabatabai, J. C. Schippers, and M. D. Kennedy, "Effect of coagulation on fouling potential and removal of algal organic matter in ultrafiltration pretreatment to seawater reverse osmosis," Water Research, vol. 59, pp. 283-294, 2014, doi: https://doi.org/10.1016/j.watres.2014.04.001.

A. A. Shehhi, M. J. Varghese, N. R. Lakkimsetty, and Walke, "Process Simulation and Optimization of Natural Gas Dehydration Process using Aspen HYSYS," International Journal of Innovative Technology and Exploring Engineering, vol. 8, no. 9, pp. 644-649, 2019, doi: https://doi.org/10.35940/ijitee.I7622.078919.

N. R. Lakkimsetty et al., "Experimental study on reducing the base sediment and water in crude oil separation," Fuel, vol. 397, p. 135478, 2025, doi: https://doi.org/10.1016/j.fuel.2025.135478.

M. S. Al-Sumri, F. Shaik, N. R. Lakkimsetty, and M. J. Varghese, "Techno-Economic Analysis of Solar and Wind Energy Systems for Power and Hydrogen Production," in Advances in Clean Energy Systems and Technologies. Cham, Switzerland: Springer, 2024, pp. 207-213. https://doi.org/10.1007/978-3-031-49787-2_19

R. Valavala, J. Sohn, J. Han, N. Her, and Y. Yoon, "Pretreatment in reverse osmosis seawater desalination: A short review," Environmental Engineering Research, vol. 16, no. 4, pp. 205-212, 2011, doi: https://doi.org/10.4491/eer.2011.16.4.205.

M. Verhuelsdonk, T. Attenborough, O. Lex, and T. Altmann, "Design and optimization of seawater reverse osmosis desalination plants using special simulation software," Desalination, vol. 250, no. 2, pp. 729-733, 2010, doi: https://doi.org/10.1016/j.desal.2008.11.031.

N. R. Lakkimsetty, H. R. A. A. Araimi, and G. Kavitha, "Modelling and optimization of well hole cleaning using artificial intelligence techniques," Discover Applied Sciences, vol. 7, p. 124, 2025, doi: https://doi.org/10.1007/s42452-024-06415-x.

J. M. Wong, J. E. Farmerie, and L. K. Wang, "Operation and Performance of Clari-DAF® System for Water Purification," in Environmental Flotation Engineering. Cham, Switzerland: Springer, 2021, pp. 343-370. https://doi.org/10.1007/978-3-030-54642-7_9

R. Vyasa, P. Brahmbhatt, C. Sonawane, N. R. Lakkimsetty, and G. Pavithra, "Investigation on the Multi-Objective Optimization of Machining Parameters and Prediction for EN Series Materials," Engineering, Technology & Applied Science Research, vol. 14, no. 5, pp. 16427-16437, 2024, doi: https://doi.org/10.48084/etasr.7953.